(精品)环氧导电腻子的用途和数据.doc

Intended Uses用途适用于防静电地坪面漆涂装前对地面进行铺平处理，以获得平整导电表面和有利涂装后道防静电面漆Used to repair and fill up the floor surface before painting with antistatic finish in order to provide smooth conductive surface for next coat.ProductInformation产品简介具有优良的刮涂性，能厚刮，干燥后不收缩，不开裂，施工方便，涂层附着力强，强度高，电阻率低、表面细腻It can be applied by doctor blade. Thick film may be obtained. After drying, no contraction or crack takes place to the film. Easy to be applied. The film possesses good adhesion, high strength, and small electric resistance. Its apperance is smooth.Application details产品数据Volume Solids 固体份90% Color 颜色Black 黑色Dry Flm Thickness干膜厚度Depending on substrate smoothness. High thickness of film can be made with doctor blade method, if necessary.与地面平整度有关该腻子可以根据平整度刮厚Theoretical Coverage 理论涂布率8.3-12.5 m2/kg（0.08-0.12 kg/ m2）），based on one coat with doctor blade application刮涂一道为8.3-12.5 m2/kg（0.08-0.12 kg/ m2　）Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Storage and Handling施工详述Mix Radio 混合比A : B=5:1(by weight) 甲:乙=5:1Method of Application 施工方法Doctor Blade 刮涂 Recommended 推荐采用 Pour the mixture on the floor and apply quickly with Doctor blade 将混合好的浆料倒在地板上，尽快刮平Airless Spray 无空气喷涂 Unsuitable 不适用 Brush or Roller 涂刷或辊涂 Unsuitable 不适用 Conwentional Spray 传统喷涂 Unsuitable 不适用 Thinner 稀释剂 Ingenral, uncessary. If necessary, use C003 一般不需要，如需要使用 C003Cleaner 油漆设备清洗剂 C003Pot Life 使用期 For Summer 夏用型：35℃：20-35 min; 25℃:30-45min For Winter 冬用型：15℃：30-45min; 5℃:45-60 minStorage 贮存期 One year 一年Drying time 干燥时间SubstrateTemperature底材温度Touch Dry表干（h）Hard Dry硬干(h）Fully Curing完全固化（d）35℃25℃15℃5℃≤4≤8≤8≤12≤8≤12≤12≤24≤1≤3≤3≤5 环氧导电腻子的用途和数据 StorageandHandling贮存与管理Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;20Kg in 20 liter container 甲:20公斤装于20公升容器中 B:4Kg in 4liter container 乙:4公斤装于4公升容器中Flash Point 闪点 ＞65℃ （Mixture, A, B） ＞65℃ (混合物、甲组份、乙组份) Specific Gravity 比重 About 1.40Kg/L 约 1.40公斤/公升来源 Specification and Surface preparation技术要求及表面处理Prior to application. All cracks, joint intersections, protrydent and hollow spots the floor have been prepared correctly and the floor has applied with primer sealer or other coatings (such as spackle or resin mortar). The surface must have been sealed up and it is smooth, clean and dry. Other information about the floor preparation methods please read the seal primer manual or consult with our company.This product can be applied directly over conductive substrate (such as metal and terrazzo anti-static.).Recommend to use the paint or summer if the substrate temperature is above 20℃ and use the paint for winter. If the substrate temperatureis in the range of 0-20℃. But the coat cures very slowly below 5℃.Must mix conponent A and B according to the pratical necessary quantity. Recommended making this paint just before painting with it. Should stir to even before application. It should be used up in its pot life in case it would cure and chould not be used.When the film is hard dry, paint with subsequent coat.在涂覆本产品前，地板上所有裂纹、接缝、凸起、凹陷、均已正确处理，并涂装了封闭底漆或其他涂层（如腻子层或树脂砂浆层），确保地面完全封闭，基本平整和清洁干燥，相关地面处理方面请参看封闭底漆说明书或向本公司咨询。

该产品也可直接在导电基材上涂装，如金属、防静电水磨石等涂装环境温度在20℃及以上时，建议采用夏用型；在0-20℃时，采用冬用型，但在5℃以下时，涂料固化缓慢使用本产品，应现用现配，用多少配多少，并充分搅拌均匀，在使用期内用完，以免凝胶浪费涂料初步干燥后，即可涂装后道涂料 Safety Precautions 安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product.This paint product contain a spot of solvent, minimal safety precautions, as follow, should be done in order to avoid danger or accident.In general this painthas no danger of explosion. However enough ventilation is necessary at application site.Because the paint is flammable, Protect skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard with ventil。