安全文件-EHS-轮式液压起重机表
Inspection ReportHYDRAULIC R/T CRANES轮式液压起重机CONTRACTOR: 承包商: _CONTROL NO. 序号: _EQUIPMENT NUMBER:设备号: _REG#:牌照: _DATE:日期: _MAKE: 制造:MODEL:型号 :_S/N:ENGINE:发动机MODEL:型号: _S/N:HOUR METER:计时表: ODOMETER:里程表:(S) INSPECTED AND SATISFACTORY（S) 经检验合格 (R) PREPAIRED AND OR ADJUSTED（R) 修理和或调整 (X) REQUIRES RECHECK AND OR REPAIR（X) 要求重检和或维修OPERATORS CAB操作室SRXStep, Door Handle, Latch踏板，门拉手，插销Seat, Seatbelt, Cleanliness座椅，安全带，室内卫生Windshield, Cab Glass风挡玻璃，驾驶室玻璃 Windshield Wiper, Washer雨刮器，喷水器Fan ( Air Circulation) 风扇( 通风)Sun Visor 遮阳板Speedometer里程表Tachometer转速计Audio, Visual Alarms声音，视觉报警器Indicators, Gauges指示器，量表Switches开关Mirrors, Rear, Left, Right左右后视镜。ELECTRICAL SYSTEM电气系统SRXHeadlights, Low / High Beam大灯。高位，低位Signal / Hazard Lights, Front Rear信号、应急灯。前后Tail Lights, Brake Lights尾灯，刹车灯Horn喇叭Back Up Lights / Alarm倒车灯，报警器Flashing Light, Cab Mounted闪光灯，驾驶室安装支架Electrical System Wiring电气系统电线Batteries, Covers, Hold Downs蓄电池。盖子，固定夹子Battery Terminals, Cables蓄电池终端，电缆ENGINE发动机SRXOil Leaks漏油Coolant Leaks冷却剂泄漏Fuel Leaks燃料泄漏Fan, Guards, Belts风扇。护罩，皮带Abnormal Exhaust Smoke异常排烟Exhaust System, Leaks, Silencer排烟系统。泄漏，消音器Radiator, Leaks, Cap, Gasket散热器。泄漏，盖子，密封垫OPERATOR STATION操作室SRXThrottle Control油门控制踏板Brake Pedal刹车踏板Transmission Controls变速系统控制Outrigger Controls叉架控制Machine Level Indicator机器水平仪Boom Hoist Control吊升降控制Angle / Range Load Chart角度、范围荷载图Boom Angle indicator吊臂角度指示器Main Winch Control主绞盘机控制Auxiliary Winch Control副绞盘机控制Boom Extension Control吊臂伸缩控制Swing & Brake Controls旋转，闸控制Cab Swing Safety Lock驾驶室旋转安全锁360 Degree Swing Lock 360度旋转锁Rear Axle Oscillation Stop Locks后轮轴振动止动锁DRIVE TRAIN驱动装置SRXFront Axle Housing, Mounting Bolts前轮轴。机架，固定螺栓Steering Knuckles, Hubs, Spindles球头，轴套，心轴Differential Planetaries, Seals, Leaks差速行星齿轮。密封件，漏油Trunnion Bearings, Mounting Bolts耳轴承，固定螺栓Rear Axle Housing, Mounting Bolts后轮轴。机架，固定螺栓Steering Knuckles, Hubs, Spindles球头，轴套，心轴Differential Planetaries, Seals, Leaks差速行星齿轮。密封件，漏油Trunnion Bearings, Mounting Bolts耳轴承，固定螺栓Drives Shafts, Front, Rear前后驱动轴Transmission, Mountings, Seals, Leaks传动装置。密封件，泄漏Transfer Case, Mountings, Seals, Leaks分动箱。固定装置。密封件，泄漏Torque Converter, Seal, Leaks液力变矩器，密封，漏油Torque Converter Drive Shaft液力变矩器，驱动轴STEERING SYSTEM方向系统SRXSteering Wheel, Linkage方向盘，联接杆Orbital Pump, Leaks轨道泵，泄漏Control Valve, Steering Box, Oil Leaks控制阀，转向机。漏油Follow Up Linkage随动联接Steering Cylinders, Oil Leaks转向助力缸BRAKE SYSTEM刹车系统SRXAir 气刹 Hydraulic 液压Brake Chambers, Linings 气制动室，衬套Rotors, Pads, Calipers转子，衬垫，卡钳Brake Tubes, Hoses, Front, Rear前后刹车管，软管Brake Test,刹车测试Parking Brake, Test手刹测试UPPER STRUCTURE上方结构SRXBoom Pedestal, Mounting bolts吊臂基架，固定螺栓Counterweight Mounting Bolts平衡锤固定螺栓Main & Auxiliary Winch Mountings主、副绞盘装置Swing Drive Motor & Brake, Noise, Leaks旋转驱动马达及制动。噪声，漏油Hydraulic Hoses, Connections, Leaks液压软管，连接件，漏油Compressed Air Lines, Connections, Leaks压缩空气管，连接件，漏油Swing Gear, Bearing & Pinion旋转齿轮。轴承及小齿轮BOOM ASSEMBLY吊臂总成SRXBoom Angle Indicator吊臂角度指示器Base Section Inspection底座检查Mounting Pins, Locks, Grease Fittings固定销，锁，黄油嘴Intermediate Section Inspections中间部分检查Tip Section Inspection顶端部分检查Inner Boom slides吊臂内部滑动Outer Boom Slides吊臂外部滑动Boom Internal Cables, Chains, Sheaves吊臂内部电缆，锁链，滑轮Hydraulic Hoses, Connections, Leaks液压软管，连接件。泄漏Point Sheaves点滑轮L
